磁翻板液位計規格型號Model

1. 基本型：適用于工作壓力低于4.0MPa，工作溫度低于200℃的液體介質的液位測量

Basic model:

Suitable for level measurement of liquid medium which working pressure less than 4.0MPa,and working temperature lower than 200℃.

2. 防腐型：適用于強酸強堿及許多有機溶劑，有不銹鋼襯四氟、PPR、PVC等多種材質可選

Anti-corrosion model:

It’s suitable for acid,alkali and many organic solvents. It use PTFE lined stainless steel,PPR,PVC as body material.

3. 夾套型：適用于需防凍，保溫及加熱場合的液位測量。夾套形式：蒸汽夾套、水循環夾套、真空夾套、電加熱、電伴熱等形式

Jacket model:

Applied to antifreeze,insulation and heating level measurement occasions. Jacket type: steam jacket,water cycle jacket,vacuum jacket,electric heating jacket,and electric warming jacket.

Jacket Type夾套形式:

a) 蒸汽夾套、水循環夾套型磁翻板液位計：主體管外加夾套層，內通蒸汽或水，用來維持測量筒內被測介質的溫度，防止被測介質因環境溫度變化發生凝固、結冰等現象。

Steam jacketed,jacketed water cycle: the main pipe plus the jacket layer,inner pass steam or water,used to maintain the temperature of the measured medium in the measurement cylinder,to prevent the measured medium temperature change occurs due to freezing,ice,etc.

b) 真空夾套型(低溫防霜型）磁翻板液位計：主體管外采用臨界點狀態下的真空夾套絕熱技術，使液位計在低溫和超低溫工藝狀態下表面不結霜。

Vacuum jacketed (low frost type): the main tube and the critical point of the vacuum jacket insulation state of technology,the level meter in the low temperature and ultra-low temperature process is not under the surface frost.

c) 電加熱型磁翻板液位計：主體管外加電加熱層，內置電加熱裝置，加熱裝置通過導熱油均勻傳遞熱量至測量筒，起到加熱保溫的作用。注：第一次使用前請加注導熱油至安全線處，否則會損壞加熱裝置。

Electric heating type: the main pipe plus electric heating floor,built-in electric heating device,heating device passes through the heat conducting oil to the measuring cylinder uniform,played the role of heat insulation. Note: before first use to raise the safety line of heat-conducting oil,otherwise it will damage the heating device.

d) 電伴熱型磁翻板液位計：主體管外加自限溫電熱帶伴熱裝置，起到加熱保溫的作用。

d) Electric warming type: the main pipe band plus a self-limiting temperature heating device,to play the role of heat insulation.

4. 高溫高壓型磁翻板液位計：適用于高溫、高壓場合的液位測量，最高工藝溫度為520℃，最大工作壓力32MPa

High temperature high pressure model:

It’s suitable for high temperature and high pressure level measurement occasions. The maximum process temperature is 520℃. The maximum working pressure is 32MPa.

5. 電子雙色式LED bi-color model:

UHZ-D型電子雙色磁浮子液位計是磁翻板液位計的換代新型產品，它可以紅綠光柱清晰顯示液位，白天觀察距離60m,夜間可達200～300m。磁翻板液位計長時間使用容易粘敷灰塵，尤其是煉鋼廠，時間一長就容易粘敷細鐵屑，把磁翻板的紅綠顏色覆蓋，使它看不到液位，另外磁翻板液位計最大的缺點就是不能發光顯示，夜間不能觀察。UHZ-D型電子雙色磁浮子液位計解決了上述問題，在電路設計上突破同類產品測量范圍小的缺點，在保證低功耗的同時，可定制任意測量高度。

UHZ-D electronic color magnetic level gauge magnetic flap is a new generation of new products,it can clearly show the red and green beam of light level during the day and viewing distance 60m,the night up to 200 ~ 300m. Level gauge magnetic flap easy to stick deposited with the dust a long time,especially in steel mills,over time it is easy to stick deposited thin iron,the magnetic flap coverage of red and green colors,so that it cannot see the level,the other Level gauge magnetic flap biggest drawback is not light show at night cannot be observed. UHZ-D electronic color magnetic sub-level gauge to solve the above problem,a breakthrough in circuit design,measurement range of similar products on minor faults,while ensuring low power consumption,any measurement can be customized highly.

與磁翻板/翻柱式指示器相比，其主要特點：

With magnetic flap / turn indicator column than its main features:

© 發光顯示：紅綠光柱清晰顯示液位，適宜在光線暗的場所中應用，夜間觀察更醒目；

LED display: red and green light beam clearly show the level,suitable for light application of dark places,night observation is more striking;

© 液位顯示清晰，色澤鮮艷，觀察角度大，可視距離遠，長時間使用不容易粘敷灰塵；

Level shows a clear,bright color,observation angle,visible from far away,long-term use is not easy to stick deposited dust;

© 設計合理、結構簡單、維修方便，被測介質與顯示系統完全分離；

Reasonable design,simple structure,easy maintenance,the measured medium and the display system completely separated;

© 適用介質廣，在鹽酸、硫酸等腐蝕性溶液中測量，具有良好的密封性。

Media widely applied in hydrochloric acid,sulfuric acid and other corrosive solution measurement,has a good seal.

主要參數Main technical parameters

溫度

Temperature

≤ 300℃

≤ 300℃

顯示顏色

Display color

液綠氣紅

Green liquid red gas

可視距離 Visible distance

60m,夜間200～300 m

60m,200 ~ 300 m at night

電源電壓

Power supply voltage

AC 220V (帶電源適配器) 或DC24V

AC 220V (with adapter) or DC24V

測量范圍

Range

可根據現場要求訂做

Requirements may be made according to the site